Close this window to return to the store

Installation Instructions 3243 Deluxe Light Kit Club Car Gas & 36V Electric ’93-UP DS

  1. Install light bulbs into headlights
  2. Using saw, cut out headlight and taillight locations Use: Templates
  3. Remove foot pad from brake pedal
    1. Install first light switch behind pedal. See Figure 1. Use: (2) #6 – 32 x 1.0” Hex bolts
    2. (2) #6 – 32 Nylon lock nuts
  4. Reinstall foot pad
    1. Install second light switch to bracket Use: (2) #6 – 32 x 1.0” Hex bolts Figure 1
    2. (2) #6 – 32 Nylon lock nuts Note: Make sure nylon lock nuts are on switch side
    1. Install switch/bracket assembly to underside of car. See Figure 2. Use: (1) 1/4” – 20 x 1.0” Hex bolt
      1. 1/4" – 20 Nylon lock nut
      2. 5/16” – 18 Nylon lock nut Note: When installed, button on light switch must be pressed in when brake pedal is stationary
  5. Using knife, cut holes in floor mat where existing holes are located in kick panel. See Figure 3.
    1. Install Dimmer switch and Horn button. See Figure 4. Figure 2Use: (2) #10 – 32 x 1.0” Slot screws
      1. #10 Lock washers
      2. #10 – 32 Hex nuts
      3. Spacers
  6. Using drill, drill a hole in dash, and install Headlight switch. See Figure 5.
  7. Install Horn. See Figure 6. Use: Existing bolt at base of steering column
  8. Connect Flasher to Signal assembly.
    1. Install Signal assembly to steering column and route wires
    2. through dash. See Figure 7. Use: Signal hardware Figure 3
  9. Install Wire harness underneath car on driver-side
  10. Connect everything per wire diagram specifications. See page 3.
  11. Install Tail and Headlights

Figure 4

3243 Light Kit Page 1 of 3 Issued: 9/26/06

Installation Instructions 3243 Deluxe Light Kit Club Car Gas & 36V Electric ’93-UP DS

Bill of Material

(2)
Headlights
(2)
Taillights
(1)
Wire Harness
(2)
Light Bulbs
(3)
Templates
(1)
Fuse Block
(1)
Ground Block
(1)
Red Power Wire with (4) Plugs
(1)
Headlight Switch
(1)
Dimmer Switch Figure 5
(1)
Horn Button
(2)
Light Switches
(1)
Light Switch Bracket
(1)
Horn
(1)
Flasher
(1)
Signal Assembly w/ Mounting Hardware
(4)
Black Screws
(4)
#6 – 32 Hex Bolts
(4)
#6 – 32 Nylon Lock Nuts
(1)
5/16” – 18 Nylon Lock Nut
(1)
1/4" – 20 x 1.0” Hex Bolt
(1)
1/4" – 20 Nylon Lock Nut Figure 6
(2)
#10 – 32 x 1.0” Slot screws
(2)
#10 Lock washers
(2)
#10 – 32 Hex nuts
(2)
Spacers

Figure 7

3243 Light Kit Page 2 of 3 Issued: 9/26/06

Installation Instructions 3243 Deluxe Light Kit Club Car Gas & 36V Electric ’93-UP DS

3243 Light Kit Page 3 of 3 Issued: 9/26/06